Product ID:BASE 2 FLOOR & DECK ALKYD ENAMEL, 630-92
MSDS Date:06/02/1986
FSC:8010
NIIN:00N034508
MSDS Number: BQBRN

O BRIEN CORP

450 EAST GRAND AVE
SOUTH SAN FRANCISCO, CA 94080
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 415-761-2300

Cage: 30806

O BRIEN CORPORATION

SOUTH SAN FRANCISCO, CA 94080-6207 US

Cage: 72556

FOR BAKING FINISHERS, VENT VAPORS EMITTED ON HEATING.

RTECS: 9999999ZZ

6

CAS: 1330-20-7

Fraction By Weight: <5%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

MINERAL SPIRITS; (MINERAL SPIRITS (ALIPHATIC PETROLEUM

CAS: 64742-88-7

Fraction By Weight: 35%

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 100 PPM

MINERAL SPIRITS; (MINERAL SPIRITS (ALIPHATIC PETROLEUM

CAS: 64742-88-7

Fraction By Weight: <5%

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 350 PPM (MFR)

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

RPTS

RTECS: 9999999ZZ

ING 1 - STUDIES SHOW XYLENE IS A

RTECS: 9999999ZZ

ING 4 - LAB STUDIES SHOW INHAL EXPOS TO HIGH LEVELS

RTECS: 9999999ZZ

TUMORS IN RATS. THIS RESPONSE DID NOT OCCUR AT LOWER

RTECS: 9999999ZZ

OVERWHELMED NORM LUNG CLEARANCE MECHANISMS. THE

RTECS: 9999999ZZ

RPTS HAVE ASSOC

RTECS: 9999999ZZ

SYS DAM. INTENTIONAL MISUSE BY DELIB

RTECS: 9999999ZZ

TO SOLV HAS BEEN SHOWN TO CAUSE DAM TO KIDNEYS,

RTECS: 9999999ZZ

(MARROW), BLOOD STORING ORGAN (SPLEEN), & PERIPHERAL

RTECS: 9999999ZZ

WIPE OFF

RTECS: 9999999ZZ

WHEN OVERSPRAY IS PRESENT. CAREFULLY FOLLOW

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: ING 1, 2 & 3 - INGEST:ASPIR OF
THIS MATL INTO LUNGS DUE TO VOM CAN CAUSE CHEM PNEUMONITIS WHICH
CAN BE FATAL. A DECISIONS TO INDUCE VOM MUST BE BASED ON MED ADVICE
FROM MD OR POIS CTL CTR. ING 4 - INGEST:LOW ORAL TOX. NO TOX EFTS
DUE TO INGEST ARE DESCRIBED IN LITERATURE. INHAL:IRRITATING TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:UPPER RESP TRACT. EYE:IRRITATING.
ACUTE: PRODUCT - INGEST:CAUSES IRRIT TO MOUTH, THROAT & GI TRACT
W/ACUTE CNS DEPRESS. SYMPS MAY INCL HDCH, DIZZ, CONFUSN, NAUS, VOM,
ABDOM PAIN, DIARR, LOSS OF CONSCIOUSNESS OR COMA.
INHAL:ANESTH;IRRIT OF RESP TRACT & ACUTE NERV SYS DEPRESS CHARACT
BY FOLLOWING (SUPP DATA)
Medical Cond Aggravated by Exposure:O'BRIEN KNOWS OF NONE LISTED IN THE
LITERATURE.

First Aid:INGEST:DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. KEEP PERS
WARM, QUIET & GET MD IMMED. DECISION TO INDUCE VOM MUST BE BASED ON
ADVICE OF MD/POIS CTL CTR. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON
PERS. INHAL:REMOVE FROM AREA TO FRESH AIR. RESTORE BRTHG. CONSULT
MD. EYE:IMMED BEGIN FLUSHING W/COOL WATER FOR AT LEAST 15 MINS,
OCCASNLY LIFTING LIDS TO ENSURE THORO RINSING. WHILE FLUSHING, (ING
15)

Flash Point:110F,43C
Lower Limits:1
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE USED TO COOL CLSD CONTRS TO PVNT PRESS BUILD-UP &
POSS AUTO-IGNITION/EXPLOS WHEN (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPARKS, FLAME & ELEC EQUIP. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT SURF (SUPP DATA)

Spill Release Procedures:REMOVE SOURCES OF IGNITION. SOAK UP & REMOVE
W/INERT ABSORBENT MATERIAL W/NON-SPARKING TOOLS. PROVIDE ADEQUATE
VENTILATION. USE NIOSH/MSHA APPROVED VAPOR RESPIRATOR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINER &
USE AWAY FROM HIGH TEMPERATURE, SPARKS & FLAME. KEEP CONTAINER
TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:AVOID PROLONGED CONTACT W/SKIN. DO NOT INGEST. KEEP
OUT OF THE REACH OF CHILDREN.

Respiratory Protection:USE NIOSH/MSHA APPRVD PROPERLY FITTED MECH RESP
OR MASK TO AVOID BRTHG VAP/SPRAY MIST DURING MIXING, SPRAYING,
APPLICATN OR CURING. USE A NIOSH/MSHA APPRVD TC 19C PROPERLY FITTED
POSITIVE AIR SUPPLIED RESP IN CONFINED AREAS OR (ING 16)
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR CONTAM
CONC BELOW APPLIC OSHA PEL OR ACGIH'S TLV LIMIT. (ING 17)
Protective Gloves:SYNTHETIC RUBBER GLOVES RECOMMENDED.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PROTECTIVE OVERALLS RECOM.
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHING. DISCARD
CONTAMINATED SHOES.
Supplemental Safety and Health
FIRE FIGHT PROC:EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQS SPEC PRECS.
DURING EMER CNDTNS, OVEREXPOS TO DECOMP PRODS MAY CAUSE HLTH HAZ.
OBTAIN MED ATTN. EFTS OF OVEREXP:PROGRESSIVE STEPS:HDCH, DIZZ, STA
G GAIT, CONFUSN, LOSS OF CONSCIOUSNESS OR COMA. EYE:CAN CAUSE SEV
IRRIT & BLURRED VISION. SKIN:CAUSE IRRIT. (ING 5)

HCC:F4
Boiling Pt:B.P. Text:>280F,>138C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:49.7

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, BASES & ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:MAY PRODUCE FUME SHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CO, CO*2 & NO*2.

Waste Disposal Methods:DISPOSE IN SEALED METAL CONTAINER AWAY FROM HEAT
& FLAME IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.